(2) American Standard 80%

This customer had remodeled his commercial property and turned 2 zones into 3. Obviously there is going to be issues with the heating system. We ended up deviding the largest zone and replacing the fuel eating inline duct heater with 2 American Standard 80% Gas Furnaces.

Heating Location 1

Heating Location 1

The picture above shows where I believe 1 of the American Standard furnaces would be located.

American Standard 80%

American Standard 80%

We build sleepers under the unit to raise it up for easier servicing and added a Honeywell 4″ pleated filter into the return system.

Heating Location 2

Heating Location 2

The 2nd location for a furnace was within the same mechanical room, besides adding sleepers we had to add a new return air duct into the space with a Honeywell 4″ pleated filter system.

American Standard 80% Furnace

American Standard 80% Furnace

The Existing supply ducting was turned and tied into the new American Standard 80% furnace.

Heating And Cooling Skagit County

Need a Heat Pump, Air Conditioner, Furnace, Boiler or Tankless Water Heater? We install them all over Skagit county including Mount Vernon WA, Burlington WA, Anacortes, Sedro Woolley, La Conner, Stanwood WA, and on Camano Is.

Anouther Monster Gone

OK I have replaced older, but I still enjoy pushing these monsters into the scrap pile. This was a Gaffers & Sattler furnace and according to the home owner installed in 1957 or 58. The serial number does show a 57. That being said it lasted 52 years … wow.

Older Furnace Gaffers & Sattler

Older Furnace Gaffers & Sattler

Our customer decided on the American Standard 95% 2 Stage Variable my best selling furnace and most favorite to install. We also installed a Honeywell 4″ pleated filter bank in the return system.

New American Standard 95% 2 stage variable furnace

New American Standard 95% 2 stage variable furnace

As you can see this was a basement application requiring an upflow furnace. I decided to add some sleepers under the furnace just in case it ever floods and because there was no drain we added a condensate pump to remove condensate from the furnace.

Bad HWT Venting

Bad HWT Venting

If you look close in the picture above you can see the HWT vent went down hill into the existing furnace vent, we also fixed this at the same time. Its never a good idea to have a vent go down hill, but in this case I think they had so much rise that it still pulled the burnt gases out.

Heating And Cooling Skagit County

Need a Heat Pump, Air Conditioner, Furnace, Boiler or Tankless Water Heater? We install them all over Skagit county including Mount Vernon WA, Burlington WA, Anacortes, Sedro Woolley, La Conner, Stanwood WA, and on Camano Is.

Arcoaire to American Standard 95%

Back in 1992 I was an Arcoaire dealer for about 3 months, I quickly left and became a York dealer for about the next 10 years. The Arcoaire furnaces where heavy, oddly sized and seemed to have a lot of “out of the box” issues. This particular furnace was starting to rack up some serious repair bills so it was time to be replaced.

Older Arcoaire Furnace

Older Arcoaire Furnace

My customer decided on the American Standard 95% Variable 2 Stage furnace, my favorite furnace to install and my top seller. Going from a 80% to a 95% she should see a reduced fuel bill as well as better comfort.

New American Standard 95% Variable Speed 2 Stage

New American Standard 95% Variable Speed 2 Stage

The American Standard is about 2.5″ deeper than the Arcoaire but width is about the same, fortunately the clearance to the front of the furnace was enough to close the door and keep mininum clearance.

New PVC Venting

New PVC Venting

The older furnace vented with regular venting, it was badly corroded to the point it would have had to be replaced if she decided to go back to a 80% furnace. The new PVC venting is almost the same size so venting the new American Standard furnace was very easy.

Venting up through deck

Venting up through deck

The PVC vent went directly outside through the exterior wall and up through their deck and then through the roof. A lot cleaner than the older corroded metal gas vent pipe.

Heating And Cooling Skagit County

Need a Heat Pump, Air Conditioner, Furnace, Boiler or Tankless Water Heater? We install them all over Skagit county including Mount Vernon WA, Burlington WA, Anacortes, Sedro Woolley, La Conner, Stanwood WA, and on Camano Is.

New American Standard Furnace Commercial

This commercial brings back some memories. You know they had a blast making these commercials. My only thought would have been to make it look a little cooler in the home … like seeing your breath on a cold day.

Heating And Cooling Skagit County

Need a Heat Pump, Air Conditioner, Furnace, Boiler or Tankless Water Heater? We install them all over Skagit county including Mount Vernon WA, Burlington WA, Anacortes, Sedro Woolley, La Conner, Stanwood WA, and on Camano Is.

Rheem to American Standard 80% High eff

In my opinion if your not worried or concerned about the federal tax credit or CNG Rebates this is the way to go. Installing a high efficient 80% with a high HSPF heat pump.

Older Rheem furnace

Older Rheem furnace

When I say high efficient 80% I’m not referring to the gas part of the furnace, but rather the motor side of the furnace. This American Standard furnace has a ECM blower motor that is estimated about 70% less to operate than a standard motor. So if you like to run your blower 24/7 for better filtration this is the way to go.

New American Standard 80% ECM

New American Standard 80% ECM

As you can see above the new American Standard 80% ECM furnace fit into place right above the new American Standard heat pump coil.

New 15 Seer American Standard Heat Pump

New 15 Seer American Standard Heat Pump

Above you see the new American Standard 15 seer heat pump, the refer line is run up the side of the garage and covered with a gutter looking chase.

Heating And Cooling Skagit County

Need a Heat Pump, Air Conditioner, Furnace, Boiler or Tankless Water Heater? We install them all over Skagit county including Mount Vernon WA, Burlington WA, Anacortes, Sedro Woolley, La Conner, Stanwood WA, and on Camano Is.

Like For Like- Trane To American Standard 95%

Even though the foot print on the new American Standard 95% 2 Stage Variable is the same as the Trane 90% it is far from the same machine.

Older Trane Furnace

Older Trane Furnace

In its day this Trane 90% was on top of its game, very efficient and durable. But at this stage of the game the owner elected to put money into a new furnace instead of repair costs.

American Standard 95% Variable Speed 2 Stage

American Standard 95% Variable Speed 2 Stage

The new American Standard bolted up exactly as the older Trane unit, but its what is in the unit that counts. The new variable speed blower with a ECM motor is far more efficient to run, helps over come air flow issues, helps balance out the home and gives us far more comfort. The 2 stage gas valve seldom operates in 2nd stage, delivering added comfort on those average to mild days. But when needed the 2nd stage really delivers the heat.

Heating And Cooling Skagit County

Need a Heat Pump, Air Conditioner, Furnace, Boiler or Tankless Water Heater? We install them all over Skagit county including Mount Vernon WA, Burlington WA, Anacortes, Sedro Woolley, La Conner, Stanwood WA, and on Camano Is.

American Standard 84% oil Furnace

Unfortunately my dad was an oil man, meaning I was raised doing oil service calls. Oil can be a very clean piece of equipment if its maintained correctly. Notice the words “maintained correctly”! Usually your changing oil to oil because the people are still happy with oil heat and do not want to invest in something way more costly. And their oil hunk of junk oil furnace is not worth fixing up. Usually that means the furnace is older than dirt and we are getting dirty!

Older Oil Furnace

Older Oil Furnace

The furnace above is an old Montag oil furnace and its lived its life. Fortunately American Standard produces a fantastic oil furnace made by Thermopride. Built like a tank and its 84% efficient. It comes with a state of the art Becket Burner assembly and in my opinion one of the best oil furnaces on the market today.

American Standard Oil Furnace.

American Standard Oil Furnace.

The new American Standard furnace slips right into position with a few minor duct and venting adjustments and its ready to run.

Dirty Duct

Dirty Duct

When you remove ducting that looks this bad then you get told to hire a duct cleaner …. HIRE A DUCT CLEANER. This piece of ducting was not near as dirty as what was in the home.

Heating And Cooling Skagit County

Need a Heat Pump, Air Conditioner, Furnace, Boiler or Tankless Water Heater? We install them all over Skagit county including Mount Vernon WA, Burlington WA, Anacortes, Sedro Woolley, La Conner, Stanwood WA, and on Camano Is.

Finally A Match – 95% American Standard

I added the American Standard air conditioner to this system over 3 years ago, at that time the customer elected not to replace the furnace. But RHEEM furnaces never let me down and now its time to replacement it, the repair bills where getting to high.

Older RHEEM unit

Older RHEEM unit

Lucky for the customer we now have the American Standard 95% Variable Speed 2 Stage gas furnace. But as you can see the newer 2000cfm units are a little wider than the older coils. So I had to make a small transition under the unit. Because we felt the system really needed a better filter system we added the Honeywell 4″ f100 filter system.

New American Standard 95% 2 stage variable speed

New American Standard 95% 2 stage variable speed

Now the customer has a matching system with an American Standard air conditioner, indoor coil and gas furnace.

Heating And Cooling Skagit County

Need a Heat Pump, Air Conditioner, Furnace, Boiler or Tankless Water Heater? We install them all over Skagit county including Mount Vernon WA, Burlington WA, Anacortes, Sedro Woolley, La Conner, Stanwood WA, and on Camano Is.