This older Lennox 80% Furnace had a control board that went beyond having a hot spot. The existing board actually caught fire and caused some alarm in the home.
Older Lennox 80% Furnace
When your furnace gets beyond 10 years of age we usually(based on expense) like to give our customers the option of repairing or replacing. And in this case you have to consider the cost of the control board and any other unknown electrical part that has failed.
New Variable Speed 2 stage 95% American Standard Furnace
If you have not figured this out by now by reading our posts is that the American Standard 95% 2 stage Variable speed gas furnace is our favorite furnace to install. We have had almost zero warranty issues caused by the manufacture. That being said we have had installation issues .. .primarily getting a good slope on the drain line when existing the right side of the cabinet. Its very hard to do with all the components in the way. BUT as you can see the furnace slipped right in to place with very little modifications. Venting changed and a condensate line added.
Heating And Cooling Skagit County
Need a Heat Pump, Air Conditioner, Furnace, Boiler, Ductless, Mini-Split or Tankless Water Heater? We install them all over Skagit county including Mount Vernon WA, Burlington WA, Anacortes, Sedro Woolley, La Conner, Stanwood WA, and on Camano Is.
My new customer was referred to Alpine by several sources … referrals is properly 90% of our business, its nice to know quality still pays off in such slow times.
Older York 80% Gas Furnace.
As you can see the existing York 80% furnace sits on a base can located in the garage. The weird part of the existing system was that the sheet rock came all the way down to the top of the furnace. It made for a little uncertainty when bidding but realistically you can pretty much tell how the ducting ran.
American Standard 95% Variable 2 Stage with Filter
After removing the existing furnace and part of the base can we cut the sheet rock up to allow for the new American Standard 95% 2 stage variable speed furnace, heat pump coil and Honeywell 4″ filter bank. By adding a heat pump coil at this point and time it allows my customer to add on a heat pump or AC at a later date without making major modifications to the existing ducting.
Heating And Cooling Skagit County
Need a Heat Pump, Air Conditioner, Furnace, Boiler, Ductless, Mini-Split or Tankless Water Heater? We install them all over Skagit county including Mount Vernon WA, Burlington WA, Anacortes, Sedro Woolley, La Conner, Stanwood WA, and on Camano Is.
This Payne 80% gas furnace was flooded out by a water leak from the floor above. Because of the extend of damages my customers insurance company decided to replace the unit.
Flooded 80% Furnace
The new American Standard 80% gas furnace slipped right into place with only some slight modifications to the supply ducting, everything else bolted right up.
American Standard NG 80% Furnace
We did add a filter access door in the existing return ducting to make it a little easier for the home owner to replace their filter. I really hate having to access a filter from inside the furnace.
Heating And Cooling Skagit County
Need a Heat Pump, Air Conditioner, Furnace, Boiler, Ductless, Mini-Split or Tankless Water Heater? We install them all over Skagit county including Mount Vernon WA, Burlington WA, Anacortes, Sedro Woolley, La Conner, Stanwood WA, and on Camano Is.
This particular customer is simply upgrading from a junky old oil furnace to an American Standard 80% furnace so he could increase the value of the home so he can get ready to sell it.
Older Oil Furnace
The existing oil furnace was framed in and somewhat concealed in the home, normally this would be a big problem, but in this case the wall is going to be removed making it fairly simple to replace.
Framed in oil furnace
Above you can see where the existing oil furnace is somewhat framed in. This type of oil furnace is called a lowboy, big and bulky is what they should call it.
American Standard 80% NG
As you can see above the old oil furnace has been removed, the back wall sheet rocked and the new American Standard 80% gas furnace installed. We included a Honeywell 4″ pleated filter bank and lined the existing chimney for proper venting of the unit.
Heating And Cooling Skagit County
Need a Heat Pump, Air Conditioner, Furnace, Boiler or Tankless Water Heater? We install them all over Skagit county including Mount Vernon WA, Burlington WA, Anacortes, Sedro Woolley, La Conner, Stanwood WA, and on Camano Is.
This older Carrier gas furnace was starting to cost the home owner more money than what the furnace was worth, honestly it should have been changed out years ago but a dollar here and a dollar there doesn’t seem so much until you add it all up.
Carrier 90% gas furnace
The existing Carrier furnace sat in a utility room downstairs next to the hot water tank. So the furnace being a upflow model was not very surprising, but very helpful.
95% American Standard gas furnace
Because the existing gas furnace was vented with PVC it made swapping over to an American Standard 95% gas furnace very easy. We simply had to make a small supply transition for the top of the furnace and then reconnect up to everything else. We did add a filter access door on the return duct for better filter access.
Heating And Cooling Skagit County
Need a Heat Pump, Air Conditioner, Furnace, Boiler or Tankless Water Heater? We install them all over Skagit county including Mount Vernon WA, Burlington WA, Anacortes, Sedro Woolley, La Conner, Stanwood WA, and on Camano Is.
Its not very often we get to install an American Standard 95% furnace in a manufactured home, mostly in part due to the sizing constraints of the equipment. A typical manufactured home furnace closet is not sized deep enough for the 95% gas furnace.
Manufactured Home Gas Furnace
One of the challenges of this particular project was keeping the air conditioning system. The existing furnace had a built in coil cabinet, the new American Standard 95% does not have this feature. So we had to make a custom AC coil cabinet that also doubled as a transitional base can.
New American Standard 95% Single Stage
Above you see the new American Standard 95% single stage gas furnace. Because we are in a manufactured home both the venting and combustion air has to be piped to the outside, this is optional in a standard home. The condensate line was tapped into the existing AC drain line. We added a Honeywell F100 4″ pleated filter bank for a filtration system and to top it off with also added a Honeywell Vision8000 thermostat.
Even though the furnace sticks out slightly into the utility room I think the payoff in savings and comfort will be worth it.
Heating And Cooling Skagit County
Need a Heat Pump, Air Conditioner, Furnace, Boiler or Tankless Water Heater? We install them all over Skagit county including Mount Vernon WA, Burlington WA, Anacortes, Sedro Woolley, La Conner, Stanwood WA, and on Camano Is.
Our customer felt it was time to replace his existing Trane 80% furnace for something more efficient that also could make his home more comfortable for his family.
Trane 80% gas furnace.
The new American Standard (manufacture of Trane) 95% fully modulating gas furnace is in my opinion the best furnace you can purchase in the industry today. Even though my favorite to install is the American Standard 95% 2 stage variable furnace, the fully modulating model is very impressive and quickly growing on me.
American Standard fully modulating 95% gas furnace.
Even though you can not tell the physical differences between the two models you can defiantly tell the difference in performance. American Standard has a fully modulating gas valve with a variable speed blower. The communicating thermostat makes less than 1% adjustments in the gas valve to maintain setpoint and has real time adaptive intelligence. No more under or over shooting the thermostats setpoint…. makes for a very comfortable heating system.
Heating And Cooling Skagit County
Need a Heat Pump, Air Conditioner, Furnace, Boiler or Tankless Water Heater? We install them all over Skagit county including Mount Vernon WA, Burlington WA, Anacortes, Sedro Woolley, La Conner, Stanwood WA, and on Camano Is.
Its not very often, but it does happen. A furnace installed in the wrong direction, well at least in my opinion its facing the wrong direction.
Rheem furnace facing wrong direction
Here you see a RHEEM 80% gas furnace facing into the garage. As you can see theres a tool box pushed up against the front of the furnace which makes it very tough to change a filter, never mind servicing.
New American Standard 95% 2 stage variable speed furnace.
As you can see above we installed the new American Standard 95% 2 stage variable speed gas furnace 180 degrees from where it was originally. Giving the home owner and service technician easy access. We also added a Honeywell F100 filter bank into the return system for even better filtration system.
Heating And Cooling Skagit County
Need a Heat Pump, Air Conditioner, Furnace, Boiler or Tankless Water Heater? We install them all over Skagit county including Mount Vernon WA, Burlington WA, Anacortes, Sedro Woolley, La Conner, Stanwood WA, and on Camano Is.